Starting Small... Building Big! With Alban CAT Construction Equipment...

Learn More
3412C Generator Set Specifications
Minimum Rating 591 ekW
Maximum Rating 800 ekW
Voltage 208 to 600 Volts
Frequency 60 Hz

Generator Set Specifications

Minimum Rating
591 ekW
Maximum Rating
800 ekW
Voltage
208 to 600 Volts
Frequency
60 Hz
Speed
1800 RPM
Height - Maximum
75 in
Length - Maximum
162.4 in
Width - Maximum
78.3 in

Generator Set Configurations

Emissions/Fuel Strategy
Low Fuel Consumption

Engine Specifications

Engine Model
3412C TA, V-12, 4-Stroke Water-Cooled Diesel
Compression Ratio
13:00:01
Aspiration
TA
Aspiration
TA
Governor Type
ADEM™ A5
Fuel System
Pump and Lines
Fuel System
Pump and Lines
Fuel System
6 in
Bore
5.4 in
Displacement
1648.86 in3
Stroke
6 in
Bore
5.4 in
Displacement
1648.86 in³
Stroke
6 in
  • Air Inlet System
    • Air cleaner, single element canister type
  • Control Panel
    • EMCP 4.2
    • Controls:
    • Run / Auto / stop Control
    • Speed Adjust
    • Voltage Adjust
    • Engine Cycle Crank
    • Emergency stop pushbutton
    • Digital Indicator for:
    • RPM
    • DC volts
    • Operating hours.
    • Oil pressure (psi, kPa or bar).
    • coolant temperature
    • Volts (L-L & L-N)
    • Frequency (Hz)
    • Amps (per phase & average)
    • Power Factor (per phase & average)
    • Warning shutdowns:
    • Low Oil pressure
    • High coolant temperature
    • Overspeed
    • Emergency stop
    • Failure to start (overcrank)
    • Low coolant temperature
    • Low coolant level
    • Communications:
    • Customer data link (Modbus RTU)
    • Accessory module data link
    • Serial annunciator module data link
    • Compatible with the following optional modules:
    • Digital I/O module
    • Local annunciator
    • Remote CAN annunciator
    • Remote Serial annunciator
    • Generator temperature monitoring module
  • Cooling System
    • Radiator with guard (sized for 50 degrees C)
    • Fan and belt guards
    • Coolant drain line with valve
    • Caterpillar extended life coolant
  • Exhaust System
    • Stainless steel exhaust flex with ANSI style outlet flange
  • Fuel System
    • Primary and secondary fuel filters
    • Fuel priming pump
    • Water separator
  • Generator and Attachments
    • SR4B self excited
    • Class H insulation
    • Class F temperature rise
    • 12 Lead
    • VR6B Voltage Regulator
    • 3 Phase sensing
    • 2:1 Volts / Hz
    • Reactive droop
    • Busbar termination
  • Governing System
    • Cat electronic governor
  • Lube System
    • Lubricating oil
    • Oil filter
    • Oil drain line with valve
  • Mounting System
    • Base, formed steel with linear vibration isolators between base and engine-generator
  • Starting / Charging System
    • 45 Amp charging alternator
    • Fuel shutoff solenoid
    • 24 Volt starting motor
    • Battery with rack, cables
  • General
    • Paint - Caterpillar Yellow except rails and radiators gloss black
  • Air Inlet System
    • Air cleaner - dual element
    • Air cleaner - heavy element
    • Air cleaner - open element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 3 Pole Circuit Breakers with shunt trip
    • 4 Pole circuit breakerswith shunt trip
    • Power terminal strips
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Common alarm / shutdown relay
    • Generator running VFC
    • Temperature monitoring package
    • Earth leakage ground fault relay
    • Vandal proof panel door
  • Cooling System
    • Radiator duct flange
    • Jacket water heater
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
    • Manifold and turbocharger guard
  • Fuel System
    • Manual Fuel transfer pump
    • Automatic fuel transfer system
  • Generator and Attachments
    • Anti-condensation heater
    • Internal excitation (IE)
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging system
    • Battery chargers
    • Battery removal
    • Oversize battery
    • Battery disconnect switch
    • Heavy duty starting system
  • Enclosures
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
    • DC Lighting package