Chat with us, powered by LiveChat

Starting Small... Building Big! With Alban CAT Construction Equipment...

Learn More
C4.4 Generator Set Specifications
Exhaust Flange Size (Internal Diameter) 63.5 mm (2.5 in)
Fuel System Electronic (adjustable)
Bore 4.13 in
Displacement 268.5 in

Engine Specifications

Exhaust Flange Size (Internal Diameter)
63.5 mm (2.5 in)
Fuel System
Electronic (adjustable)
Bore
4.13 in
Displacement
268.5 in
Stroke
5 in
Engine Model
C4.4, In-line 4, 4-cycle diesel
Compression Ratio
18.2:1
Governor Type
Adem™A4
Fuel System
Electronic (adjustable)
Bore
4.13 in
Displacement
268.5 in
Stroke
5 in

Generator Set Specifications

Minimum Rating
36 ekW
Maximum Rating
100 ekW
Voltage
220-480 Volts
Frequency
60 Hz
Speed
1800 RPM
Width - Maximum
44.1 in
Height - Maximum
53.6 in
Length - Maximum
75.8 in

Generator Set Configurations

Emissions/Fuel Strategy
Non Regulated, EU Stage II
  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Cooling System
    • Radiator and cooling fan with guards
    • Coolant drain line with valve
    • Fan drive, battery charging alternator drive
    • Caterpillar extended life coolant
  • Control Panel
    • EMCP 4.1
  • Exhaust System
    • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
  • Fuel System
    • Standard open set fuel tank / base supplied base, formed steel with single wall integral 8-hour fuel tank
  • Generator
    • 12 leads
    • IP23 protection
    • Voltage regulator (single phase sensing)
    • Tower panel, IP22, bottom cable entry
    • Segregated low voltage (AC/DC) wiring panel
    • Circuit breaker, IEC, 3 pole, mounted in tower panel
  • Governing System
    • Mechanical and electrical governing system - model dependent
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Captive linear vibration isolators between base and engine-generator
    • Includes lifting provision and drag points
    • Termination points for coolant and lube oil drain lines
  • Starting/Charging System
    • 24V battery with rack and cables
  • General
    • Engine and alternator pre-paint, Caterpillar yellow
  • Alternator System
    • R frame auxilliary winding
    • LC frame alternator
    • LC frame alternator with coastal insulation protection
    • Permanent magnet
    • 3 phase sensing
    • Quadrature droop kit
    • Anti-condensation heater
  • Circuit Breakers
    • Circuit Breaker Upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
  • Cooling System
    • Coolant heater
    • Low coolant temp alarm
    • Low coolant level shutdown
  • Control Panel Options
    • EMCP 4.2
    • Volt free contacts
    • Speed adjust potentiometer
    • Voltage adjust potentiometer
    • Panel mounted audible alarm
    • Earth fault (2 wire only)
    • Earth leakage (2 wire only)
    • Overload shutdown via breaker
    • Battery charger
    • Emergency stop with key
    • Control panel heater
  • Enclosures
    • Sound attenuated Level 2 enclosure
    • Sound attenuated Level 1 (galv)
    • Rental pack - CAE rental option only
  • European Certifications
    • Upgrade to STD set for CE
  • Fuel System
    • Open set narrow base
    • Compact skidbase for open set
    • Skidbase for CALG enclosure sets
    • Bunded fuel tank
    • Low fuel level shutdown
    • Low fuel level alarm
    • High fuel level alarm
  • Global Certifications
    • Certification for CIS
  • Mounting Options
    • Electronic governor
    • Battery removal
    • External single point lift - enclosure
    • Industrial silencer
    • Silencer installation kit
  • Special Packing/Inspectons for Shipment
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
  • General - Accessories / Miscellaneous
    • Stone guards / rad trans flange
    • Packing case - compact set
    • Packing case - canopied set